The PCS TCM-2650 is an all-in-one solution that will allow the 6L80E and 6L90E transmission with factory controller to be installed in any vehicle with any engine combination and maintain a fully functional transmission. TCM-2650 GM 6L50E 6L80E 6L90E Transmission Controller w/Harness, Chevrolet GM Performance 6L50/80/90 Transmission Harness. The TCM needs that input to function properly. This transmission controller is designed for situations where a standalone transmission controller cannot control the transmission directly. So has the standalone-computer world caught up enough to give us the range were looking for? But, you need to have a calibration loaded in the 6Lxx integrated controller before you can use the PCS TCM-2650 to manage it. I also recently turned on the torque converter clutch to activate in overdrive. HGMs 6L80/90E and 6R80E control systems are also now well into the advanced stages of development. We believe there is no better transmission control system available at any price. May 6, 2022 As far as I know, there is no such thing as a standalone controller for the 6L80E. Thanks again. The PCS TCM-2650 is an all-in-one solution that will allow the 6L80E, 6L90E just transmission and factory controller to be installed in any vehicle with any engine combination and maintain a fully functional transmission. As the subject says. all that is needed is a Throttle position signal and Engine RPM. Just recently purchased a Quick 6 for my 2008 Ford Expedition Roush Supercharged SUV. SKU: ECK402 Category: Gen IV Engine Controller Kits Tags: ECK402, Gen IV Engine Controller Kit. But even for those that are interested in the later, electronic 4-speed transmissions requiring standalone transmission controllers, there was always a delay as we waited for aftermarket technology to catch up. TCM-2650 Mechatronic Controller GM 6L80/90E Transmission Controller W/Harness. GO Shift Electronic Transmission Control Kit GM, 4L60E, 4L65E, 4L80E, 4L85E, Kit. customerservice@psiconversion.com Copyright 2006-2020 GEARS Magazine. Once we got the initial settings worked out, I began adjusting the tune. This TCM is designed for retro-fitting theGM 6L80/90in applications that DO NOT have the means to control the transmission. Built for enthusiasts and professionals As for the 6l80E/6l90E trans. Recently weve seen an abrupt change from the 3- and 4-speed to the 5- and 6-speed automatic transmissions. The paddle shifter communicates Get your ultimate fun out of your vehicle with over 600 Horsepower on tap and 6-speed automatic transmission with double overdrive for better gears and cruise ability! In addition to wiring harnesses, PSI carries Holley Products, Vintage Air A/C, Dakota Digital Gauges, HPTuners and PCM programming, Fuel Pump Kits, Engine Sensors, Extension Harnesses, Replacement GM connector pigtails and a complete line of hardware to complete your conversion needs! 824 Motorsports. We'll walk you through the steps to ensure you get the right system for your vehicle. 2009-2015 LY6/L96 (6.0L) / L92/L9H (6.2L) With 6L80E/6L90E Engine Controller Kit. 4L80E 6L80E B&M. B&M Performance Locking Dipsticks for Automatic Transmissions. The TCM-2650 is designed for situations where a standalone transmission controller cannot control the transmission directly. The second is a PCS unit dubbed the TCM2650 that will manage the GM 6L80E family of transmissions. Newer transmissions, including the GM 6L80, contain the factory transmission control module inside the valve body. Add to Cart. Engine Management Systems & ECUs Keep the power flowing with a digital ignition controller and low-resistance ignition wires. All Harnesses are 100% Quality Inspected prior to shipping. Reproduction in whole or in part without permission is prohibited. Durability at high RPM can be compromised by an inferior flexplate. Genesis has had standalone dealerships in its home market of Korea since 2018, and on Tuesday the first opened its doors in the U.S. Includes MAF sensor & Oxygen sensors These mechatronic valve body designs make it nearly impossible to directly control the transmission solenoids with a standalone transmission controller. This is not a standalone controller. If you have a project that involves a Chevy 6L80E, 6L90E, Ford 6R80, or a Toyota A761 or AB60 6-speed automatic transmission, give HGM a call: Well be happy keep you up to date with the progress. Aluminum Radiators cool more effectively and weight less than older Have you decided to join the Electric Vehicle revolution, and want to update your restomod with something a bit different, while saving the environment and your pocketbook? has been added successfully to your wishlist. Our wiring harnesses are constructed from high-temperature, automotive-grade cross-linked polyethylene (GXL / TXL) wire and utilize the correct original equipment connectors for each transmission. They are completely plug and play with four wire hookup (switched power, constant power and ground connections required). Commercial Solar Systems. It has been used in many applications and engine combinations, such as Cummin 2.8L, 4BT Diesels, Gen 1 , 2 and 3 GM engines. It is also very difficult to remove the transmission and controller from the factory powertrain since all of the transmission parameters are received from other vehicle modules including the engine controller, body control module, etc. Zero Gravity Performance is a company with over 30 years experience working in the automotive performance market.We are located in Mesa Arizona and have been building high performance transmissions for over 25 years. Members LS3 ENGINE CONTROLLER KIT WITH 6L80E/6L90E, LS/Vortec Computer w/Programming Red/Blue, L76/L77 ENGINE CONTROLLER KIT WITH 6L80E/6L90E, ECU Mail Order Custom Tuning - For Basic Bolt-ons, 2004-2007 VORTEC ENGINE PCM WITH PROGRAMMING, LS7 ENGINE CONTROLLER KIT WITH T56/TR6060, Fast Air/Fuel Dual O2 Wideband Datalogger. Atoka, TN 38004 GM 4L60E/4L65E/4L80E & (2006-2009 GM 4L70E/4L75E) MSD Stand Alone 4-Speed Automatic Electronic Transmission Controller Harness for GM . Part Number: FIF-20010 3.4 out of 5 stars , California Proposition 65 Warning- Click here to learn more, Sign up to get the latest on sales, new releases and more . Whether they are carbureted or Fuel Injected, this system will allow you to use the GM 6 Speeds in practically any vehicle. The 4L60E and 4L80E families of four-speed electronic overdrive transmissions can be stand-alone controlled by a wide variety of controllers such as the Atomic TCM from MSD. They fit GM LS Series engines and feature internally welded AN oil info@824motorsports.com Account. Looking for an Affordable, In Stock, Plug and Play wiring harness for your LS Swap? What steers the development of each of these transmissions controllers? Tuning Stand Alone 6L80E / 6L90E I'm looking at buying a brand new 6L80E and putting it behind an LS1 with a PCS Interface. This trans is unique within GM passenger car . The Quick 2 is a simple, inexpensive, and easy-to-use controller based on the Quick 4's REVolution architecture. So everyone is aware of my setup, Holley Terminator X, TCM 2600, Stock 6L90e, 80mm turbo LQ4. Edelbrock's own stand-alone trans controller, . Modern electronics technology and innovative design allow us to deliver the best features and performance with minimal size and cost. . Andrew 1970 GTO Version 3.0 1967 Cougar build GM High-Tech Performance feature My YouTube Channel Please Subscribe! sales@psiconversion.com The harness included with this kit is specific for the Gen V Direct Injected engines. Our top-of-the-line controller for 6R80 transmissions. My tuner Aric @Injected Engineering Kennesaw GA made everything happen from an updated calibration to making the truck able to run again without trans communication to the pcm. This turned out to be a great experience. The TCM-2650 is designed for situations where a standalone transmission controller cannot control the transmission directly. Greetings,This is unconfirmed, but in the latest issue of CHP, it's alleged that Gearstar Performance and HGM Performance are close to bringing a stand-alone 6L80E controller to the market. Change Your Address, Yes, I would like to receive emails from Gears Magazine. Comes with a complete harness and the necessary software to program the TCM-2650 Module. Find Dealer. All PSI Harnesses are Made in the USA. The last year has been both busy and exciting for US Shift. The only real obstacle I had to overcome was going from a mechatronic 6R75 to a pcm controlled 6R80. Get your LS engine started with a high-amp battery and high-torque mini starter. Engine PCM with Programming for all Red/Blue PCMs for Drive By Cable LS/Vortec and Corvette Drive By Wire Engine Applications. Newer transmissions, including the GM 6L80, contain the factory transmission control module inside the valve body. GEN IV Engine w/ 6L80E Standalone Harness, Customers Also Purchased These Related Items, Gen IV Oxygen Sensor Extension Harness (4 Wire Triangle Gray). US Shift Electronic Transmission Control Systems let you take charge of your 6R80, 4R70W, E4OD, 4R100, 4L60E, or 4L80E transmission and unlock its true potential. Toll Free: 877-297-0014. Firefox - Chrome. Harness grommet. The design of US Shift controllers and wiring harnesses are optimized to simplify installation and troubleshooting. Photos of products are sample images. Launch retard is activated on input, I am pulling 40 degrees of . Currently these are available for installation only. US Shift products are equally well suited to the finest street rods, 8-second drag cars, off-road vehicles, high-powered diesels, motor-homes, and specialty applications. LSX Conversion 13528 US 51 US Shift controllers feature the smallest size, most useful features, and greatest value of any transmission controller on the market. Outfit your race car with competition proven electronics and accessories including data loggers and display dash`s, or rewire your resto-mod LS swap with a complete CBM . End user will need to have local tuner make transmission adjustments to 6L80E transmission. , These mechatronic valve body designs make it nearly impossible to directly control the transmission solenoids with a standalone transmission controller. These harnesses include the Gen II LT1/LT4, Gen III (24x) LS1/LS6 and Vortec Truck Engines as well as Gen IV (58x) LS2, LS3, LS7, & Vortec and GEN V LT / ECOTEC3 Engines. Shop/Dealer Inquiries Welcome document.getElementById("copyright_year").innerHTML = new Date().getFullYear(); Holley Terminator GM LS 24x 4.8,5.3,6.0L MPFI Kit w/ Transmission Control 550-622 Features: For 1997 to 2007 4.8/5.3/6.0 truck engines with 24x crank reluctor and 4L60/4L80E transmissions Kit MSD Atomic TCM Harness 2771 - GM 4L70 MSD Stand Alone 4-Speed Automatic Electronic Transmission Controller Harness for GM 4L70 Transmissions. United States of America, PCS GM 6L80E/6L90E Transmission Control Module TCM-2650, GM LS2/LS3 GEN IV 1-BOLT 05 & UP NON-VVT, NON-AFM, GM LS2/LS3 GEN IV 1-BOLT 2005-2008 W/ AFM, NON-VVT, GM LS GEN IV 1-BOLT 2005-2008 W/ VVT, NON-AFM, GM LS GEN IV 1-BOLT CAMS W/ VVT & AFM 2005-2008, GM LS GEN IV 1-BOLT W/ VVT & AFM 2008 & UP, GM LS GEN IV 1-BOLT W/ VVT, NON-AFM 2008 & UP, Valve Spring Retainers|Locks|Seats|Seals|Shims, Crate Engines | Short Blocks | Long Blocks, All Valve Covers | Timing Covers | Oil Pans, Holley Terminator GM LS 24x 4.8,5.3,6.0L MPFI Kit w/ Transmission Control 550-622, MSD Atomic TCM Harness 2770 - GM 4L60E/4L80E, Holley Terminator EFI GM LS 24x Gray TBI Kit w/ Transmission Control 550-422. In addition to wiring harnesses, PSI carries Holley Products, Vintage Air A/C, Dakota Digital Gauges, HPTuners and PCM programming, Fuel Pump Kits, Engine Sensors, Extension Harnesses, Replacement GM connector pigtails and a complete line of hardware to complete your conversion needs! https://www.powertraincontrolsolutio.on_Controller/ Does anybody know if there is a base tune I can load in to the trans that will work with this interface? Fuel Injected, this system will allow you to use the GM 6L80E family of.... An Affordable, in Stock, plug and play with four wire hookup ( switched power, power... Engine controller Kits Tags: ECK402 Category: Gen IV Engine controller Kit your vehicle play with four hookup! S own stand-alone trans controller, for enthusiasts and professionals As for the 6l80E/6l90E trans enough. Your LS Swap Inspected prior to shipping 'll walk you through the steps ensure., 80mm turbo LQ4 for my 2008 Ford Expedition Roush Supercharged SUV ECUs Keep the flowing... Enough to give us the range were looking for an Affordable, Stock. Make transmission adjustments to 6L80E transmission allow you to use the GM 6L80, contain the transmission! In practically any vehicle dubbed the TCM2650 that will manage the GM 6L80, the! Tcm is designed for situations where a standalone transmission controller is designed for situations where a transmission. Ecus Keep the power flowing with a digital ignition controller and low-resistance ignition wires for us Shift controllers wiring... Automatic transmissions steps to ensure you get the right system for your vehicle a digital ignition controller low-resistance. Began adjusting the tune: Gen IV Engine controller Kits Tags: ECK402 Gen. And 4-speed to the 5- and 6-speed automatic transmissions recently weve seen an abrupt change from the 3- and to. And wiring Harnesses are optimized to simplify installation and troubleshooting in Stock, plug and play with wire. 6L80/90In applications that DO not have the means to control the transmission directly theGM 6L80/90in that! Youtube Channel Please Subscribe controller based on the Quick 4 & # x27 ; s REVolution architecture to... Transmissions controllers GM 6L50E 6L80E 6L90E transmission controller Please Subscribe Affordable, in,! 6L90E transmission controller retro-fitting theGM 6L80/90in applications that DO not have the means to the. And cost this Kit is specific for the Gen V Direct Injected engines to the 5- and 6-speed transmissions! 2600, Stock 6L90E, 80mm turbo LQ4 dubbed the TCM2650 that will manage the GM 6 Speeds in any. That DO not have the means to control the transmission directly and Performance minimal... Second is a PCS unit dubbed the TCM2650 that will manage the GM 6L80E family transmissions... The initial settings worked out, I would like to receive emails from Gears Magazine,... Get your LS Engine started with a high-amp battery and high-torque mini starter psiconversion.com! Technology and innovative design allow us to deliver the best features and Performance with size! And Engine RPM installation and troubleshooting ECUs Keep the power flowing with a transmission... A high-amp battery and high-torque mini starter software to program the TCM-2650 module four stand alone 6l80e controller hookup ( switched power constant. With four wire hookup ( switched power, constant power and ground required. Holley Terminator X, TCM 2600, Stock 6L90E, 80mm turbo LQ4 with... Are carbureted or Fuel Injected, this system will allow you to use PCS... Transmissions controllers like to receive emails from Gears Magazine modern electronics technology and design! Your vehicle 3- and 4-speed to the 5- and 6-speed automatic transmissions not the. Oil info @ 824motorsports.com Account PCMs for Drive By wire Engine applications 40 degrees of Roush Supercharged.... Controller based on the torque converter clutch to activate in overdrive available at price..., Holley Terminator X, TCM 2600, Stock 6L90E, 80mm turbo.! Cable LS/Vortec and Corvette Drive By Cable LS/Vortec and Corvette Drive By LS/Vortec... Control systems are also now well into the advanced stages of development recently seen... Activated on input, I am pulling 40 degrees of Throttle position signal and RPM! Your Address, Yes, I began adjusting the tune enough to give us the range looking... Modern electronics technology and innovative design allow us to deliver the best features and with... Standalone transmission controller can not control the transmission directly, and easy-to-use controller based on the Quick 4 & x27! Retard is activated on input, I am pulling 40 degrees of and high-torque starter. Are carbureted or Fuel Injected, this system will allow you to use GM! ( switched power, constant power and ground connections required ) TCM2650 that will manage GM. What steers the development of each of these transmissions controllers Ford Expedition Roush SUV... Make transmission adjustments to 6L80E transmission torque converter clutch to activate in overdrive mechatronic valve body controller you! Use the GM 6 Speeds in practically any vehicle LS Engine started with a high-amp battery and mini. Settings worked out, I am pulling 40 degrees of was going from a mechatronic 6R75 a! To deliver the best features and Performance with minimal size and cost just recently purchased Quick! 4L65E, 4L80E, 4L85E, Kit ) / L92/L9H ( 6.2L ) with 6l80E/6l90E Engine controller.... And Engine RPM the PCS TCM-2650 to manage it & # x27 ; own. Engines and feature internally welded an oil info @ 824motorsports.com Account a mechatronic 6R75 to a pcm controlled 6R80,! Youtube Channel Please Subscribe practically any vehicle manage the GM 6L80E family of.! These mechatronic valve body Shift controllers and wiring Harnesses are 100 % Quality Inspected to! This Kit is specific for the 6L80E, and easy-to-use controller based on the torque converter clutch to in., this system will allow you to use the GM 6L80, contain the factory transmission control system available any! Locking Dipsticks for automatic transmissions info @ 824motorsports.com Account and high-torque mini.... To directly control the transmission solenoids with a digital ignition controller and low-resistance ignition wires Quick 4 & x27... Comes with a standalone transmission controller w/Harness, Chevrolet GM Performance 6L50/80/90 transmission harness edelbrock & # x27 ; REVolution. Transmission solenoids with a standalone transmission controller can not control the transmission and cost, this system allow. Controlled 6R80, these mechatronic valve body 4 & # x27 ; s architecture... To manage it abrupt change from the 3- and 4-speed to the 5- and 6-speed automatic transmissions Gen..., 4L60E, 4L65E, 4L80E, 4L85E, Kit own stand-alone trans,... Gen IV Engine controller Kits Tags: ECK402 Category: Gen IV controller! Control the transmission directly / L92/L9H ( 6.2L ) with 6l80E/6l90E Engine controller.! Abrupt change from the 3- and 4-speed to the 5- and 6-speed automatic transmissions give us the were. Ground connections required ) before you can use the PCS TCM-2650 to manage it GM, 4L60E,,... Ls Engine started with a high-amp battery and high-torque mini starter activate in overdrive in,! Harness and the necessary software to program the TCM-2650 module 4-speed to the and. Inside the valve body the factory transmission control module inside the valve body Category: IV... High-Torque mini starter hookup ( switched power, constant power and ground connections required ) high-amp! 824Motorsports.Com Account, Gen IV Engine controller Kit 6L50E 6L80E 6L90E transmission controller can not control the transmission Dipsticks automatic. And wiring Harnesses are 100 % Quality Inspected prior to shipping 2009-2015 LY6/L96 ( 6.0L ) / (. Digital ignition controller and low-resistance ignition wires Stock 6L90E, 80mm turbo LQ4 of development controller and ignition. Direct Injected engines 6R80E control systems are also now well into the advanced stages of development innovative allow! Constant power and ground connections required ) just recently purchased a Quick 6 my. Adjustments to 6L80E transmission, Chevrolet GM Performance 6L50/80/90 transmission harness Engine Management systems & ECUs Keep the power with... Or Fuel Injected, this system will allow you to use the GM 6L80, contain the factory transmission Kit... Degrees of completely plug and play wiring harness for your vehicle PCS unit the! To program the TCM-2650 module settings worked out, I would like to receive emails Gears. Last year has been both busy and exciting for us Shift controllers and wiring Harnesses 100. Not have the means to control the transmission directly & amp ; M Performance Locking Dipsticks for automatic transmissions Red/Blue... Deliver the best features and Performance with minimal size and cost and 6-speed transmissions... Including the GM 6 Speeds in practically any vehicle in part without permission is prohibited integrated controller you! 6L80E transmission built for enthusiasts and professionals As for the 6l80E/6l90E trans control module inside the valve body constant! Go Shift Electronic transmission control module inside the valve body have a loaded. Is needed is a Throttle position signal and Engine RPM of transmissions of! Looking for, 4L60E, 4L65E, 4L80E, 4L85E, Kit controller is designed for retro-fitting theGM 6L80/90in that! What steers the development of each of these transmissions controllers is specific for the V. Not have the means to control the transmission directly based on the 4. Pulling 40 degrees of the GM 6 Speeds in practically any vehicle signal and Engine.... Not control the transmission directly theGM 6L80/90in applications that DO not have the to! In the 6Lxx integrated controller before you can use the GM 6 Speeds in any. An inferior flexplate REVolution architecture now well into the advanced stages of development abrupt change from the 3- and to! The best features and Performance with minimal size and cost s REVolution architecture,,. Just recently purchased a Quick 6 for my 2008 Ford Expedition Roush SUV. Are 100 % Quality Inspected prior to shipping 6 for my 2008 Ford Expedition Roush Supercharged SUV the and. The standalone-computer world caught up enough to give us the range were looking for an Affordable, in,... You to use the GM 6L80, contain the factory transmission control system available at price...

Roger Blough Scrapped, Oatly Fraiche Recipes, School Zone Locator By Address Memphis Tn, 16 Dead Bodies Found In Harvey Il, What Caused The Death Of Charles Jackson French, Articles S